Digital technology for growing alkali halide crystals in an argon atmosphere based on the Bridgman method
DOI:
https://doi.org/10.32523/ejpfm.2026100205Keywords:
alkali halide crystal (AHC), single crystal, crystal growth, Bridgman method, X-ray luminescence (XRL), radiation defects, exciton-like luminescenceAbstract
A process for the purification and growth of alkali halide crystals (AHCs) has been demonstrated using the KCl:Li crystal as a representative example. The experiments were performed on an experimental crystal growth setup manufactured by Across International (USA). The procedure comprised the following sequential stages: (i) establishment of a deep static vacuum ( 10????3 Pa or 10????6 Torr) within a quartz reactor containing a quartz ampoule with a raw material; (ii) introduction of high-purity argon at room temperature to a pressure of 0.3–0.5 bar, calculated to reach 1.1–1.3 bar at the melt temperature of the material (770–800°C), in order to suppress the evaporation of aggressive halogen vapors. Crystal growth was conducted in strict accordance with the protocol of the Eurotherm system and the MCGS (Monitor and Control Generated System) human–machine interface (HMI) platform. Owing to this integrated control architecture, a controlled slow-cooling regime of the “superheated” crystal at a rate of 20–30 C/h was implemented, a capability not previously attainable in comparable crystal growth systems. The newly developed integrated crystal growth system differs fundamentally from conventional designs and does not require: (i) quartz-sealing laboratory facilities for ampoule sealing, since the raw material within the quartz ampoule is maintained under vacuum inside the quartz reactor; (ii) additional water cooling of the installation, as the crystallization center is formed close to the thermal block and ends of the quartz tube are positioned outside the high-temperature zone. In a test regime, X-ray luminescence (XRL) spectra of freshly grown KCl:Li crystals were recorded as a function of lithium ion concentration. The anticipated enhancement of the luminescence light yield was observed, attributed to the recombination assembly of electron–hole pairs within the field of lithium ions. The result constitutes an important parameter for the development of the scientific basis of scintillation detectors.
References
[1] K.S. Song, R.T. Williams, Self-trapped excitons (Berlin: Springer, 2013) 410 p.
[2] C.B. Lushchik, A.Ch. Lushchik, Decay of electronic excitations with defect
formation in solids (Moscow: Nauka) (1989). (In Russian)
[3] C. Lushchik, A. Lushchik, Phys. Solid State 60 (2018) 1487–1505.
[4] A. Lushchik, Ch. Lushchik, E. Vasil’Chenko, A.I. Popov, Low Temp. Phys. 44 (2018) 269–277.
[5] E.D. Aluker, D.Yu. Lusis, S.A. Chernov, Electronic excitations and
radioluminescence of alkali halide crystals (Riga: Zinatne, 1979) 251 p. (In Russian)
[6] Y. Takizawa et al., J. Cryst. Growth 573 (2021) 126287.
[7] Y. Takizawa et al., Jpn. J. Appl. Phys. 61 (2022) SC1009.
[8] K. Miyazaki et al., Radiat. Phys. Chem. 207 (2023) 110820.
[9] A. Seguchi et al., Opt. Mater. 168 (2025) 117406.
[10] Y. Yoshikawa et al., Radiat. Phys. Chem. 215 (2024) 111367.
[11] H. Kimura et al., J. Lumin. 236 (2021) 118099.
[12] S. Lee, J. Lee, G. Kim, S.J. Ye, Nucl. Instrum. Methods Phys. Res. A 1050 (2023) 168141.
[13] M. Behmadi et al., Nucl. Eng. Technol. 56(2) (2024) 753–761.
[14] C. Iliaskou et al., Z. Med. Phys. (2025).
[15] E. Saeedian et al., Radioprotection 60(1) (2025) 57–64.
[16] L. Bossin et al., Radiat. Meas. 188 (2025) 107504.
[17] S. Lee et al., Nucl. Instrum. Methods Phys. Res. A 1050 (2023) 168141.
[18] S.P. Voss et al., Radiat. Meas. 46 (2011) 1590–1594.
[19] A. Romanyukha et al., Radiat. Meas. 108 (2018) 45–51.
[20] E.B. Jumpeno et al., Atom Indones. 50 (2024) 267–271.
[21] M. Alizadeh et al., J. Biomed. Phys. Eng. 12(2) (2022) 111–116.
[22] N. Salah, P.D. Sahare, A.A. Rupasov, J. Lumin. 124 (2007) 357–364.
[23] Y.S. Horowitz, L. Oster, I. Eliyahu, J. Lumin. 214 (2019) 116527.
[24] H.R. Baghani, M. Goli, E. Koushki, M. Robatjazi, Results Opt. 18 (2025) 100778.
[25] L. Prouzova Prochazkova et al., Radiat. Phys. Chem. 237 (2025) 112991.
[26] Z. Lagha Ameur, P. Lonski, T. Kron, Radiat. Meas. 192 (2026) 107626.
[27] X. Li et al., Nano-Micro Lett. 17(1) (2025) 160.
[28] P. Mangthong et al., Radiat. Phys. Chem. 237 (2025) 113010.
[29] A.A. Patil et al., Anal. Methods 17(8) (2025) 1754–1764.
[30] K. Shunkeyev et al., Nucl. Instrum. Methods Phys. Res. B 509 (2021) 7–11.
[31] K. Shunkeyev et al., Nucl. Instrum. Methods Phys. Res. B 509 (2021) 1–6.
[32] K. Shunkeyev et al., J. Lumin. 284 (2025) 121308.
[33] L. Myasnikova et al., Nucl. Instrum. Methods Phys. Res. Sect. B 464 (2020) 95–99.
[34] K. Shunkeyev et al., J. Phys. Conf. Ser. 830 (2017) 012138.
[35] Y. Li, M. Cotlet, I. Hadar, P. Guo, Chem. Commun. 60(99) (2024) 14806–14809.
[36] Y. Kohzuki, T. Ohgaku, J. Lumin. 253 (2023) 119469.
[37] M. Barth, W. Lorke, E. Mohler, Phys. Status Solidi B 130 (1985) 457–466.
[38] W. Qi et al., Phys. Lett. A 538 (2025) 130351.
[39] S. Mahlik, M. Malinowski, M. Grinberg, Opt. Mater. 33 (2011) 1525–1529.
[40] S. Mahlik, High-pressure study of phosphors emission, in: R.-S. Liu, X. Wang
(Eds.), Phosphor Handbook: Experimental Methods for Phosphor Evaluation and
Characterization (Boca Raton: CRC Press, 2022) pp. 419–545.
[41] K. Shunkeyev et al., Nucl. Instrum. Methods Phys. Res. B 528 (2022) 20–26.
[42] R. Gindina, A. Maaroos, L. Ploom, N. Jaanson, Development of the method
of preparing KCl and KBr crystals containing impurities, in: Electronic
excitations and defects in ionic crystals (Tartu: Academy of Sciences of the
Estonian SSR, Institute of Physics) (1979) pp. 45–89. (In Russian)
[43] Across International, 1200 _ C 3-zone crystal growth tube furnace with
Kanthal heating elements, swing open chamber.
[44] Sherwood Scientific Ltd., Model 410 flame photometer.
[45] K. Shunkeyev et al., Crystals 13(2) (2023) 364.
[46] C. Lushchik et al., Phys. Status Solidi B 114(1) (1982) 103–111.
[47] R. Onaka, I. Fujita, A. Fukuda, J. Phys. Soc. Jpn. 18 (1963) 263–268.
[48] A.Z. Bekeshev, K.Sh. Shunkeyev, E.A. Vasil’chenko, A.A. Elango, Phys. Solid State 39 (1997) 75–76.
Downloads
Published
Issue
Section
License
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
